A rocket-propelled grenade (often abbreviated RPG) is a shoulder-fired, anti-tank weapon system that fires rockets equipped with an explosive warhead. These warheads are affixed to a rocket motor and stabilized in flight with fins. Some types of RPG are reloadable, while others are single-use. RPGs, with some exceptions, are generally loaded from the muzzle.
RPGs with high explosive anti-tank warheads (HEAT) are very effective against armored vehicles such as armoured personnel carriers (APCs). However, heavily armored vehicles, such as main battle tanks, are generally too well armored to be penetrated by an RPG, unless weaker sections of the armor are exploited. Various warheads are also capable of causing secondary damage to vulnerable systems (especially sights, tracks, rear and roof of turrets) and other soft targets.
The term "rocket-propelled grenade" is strictly a backronym; it stems from the Russian language РПГ or ручной противотанковый гранатомёт (transliterated as "ruchnoy protivotankovy granatomyot"), meaning "hand-held anti-tank grenade launcher", the name given to early Russian designs.
The RPG has its roots in the 20th century with the early development of the explosive shaped charge. Before the adoption of the shaped charge, anti-tank guns and tank guns relied primarily on kinetic energy to defeat armor. As tank armor increased in thickness and effectiveness, the guns needed to defeat them became increasingly heavy, cumbersome and expensive, meaning that infantry could find themselves defenseless against tanks. Armies found that they needed to give infantry the means to defeat enemy armor when no anti-tank guns were available. Initial attempts to put such weapons in the hands of the infantry resulted in weapons like the Soviet RPG-40 blast effect hand grenade (here RPG stood for ruchnaya protivotankovaya granata, meaning hand-held anti-tank grenade). The later RPG-43 and RPG-6 used shaped charges, the chemical energy of their explosive being used more efficiently to enable the defeat of thicker armor; however, being hand thrown weapons, they still had to be deployed at suicidally close range to be effective. What was needed was a means of delivering the shaped charge warhead from a distance. Different approaches to this goal would lead to the anti-tank spigot mortar, the recoilless rifle and, from the development of practical rocketry, the rocket propelled grenade.
Research occasioned by World War II produced such weapons as the American bazooka and German Panzerfaust, which combined portability with effectiveness against armored vehicles, such as tanks. The Soviet-developed RPG-7 is the most widely distributed, recognizable and used RPG in the world. The basic design of this RPG was developed by the Soviets shortly after World War II in the form of the RPG-2, which is similar in function to the bazooka and the Panzerfaust.
Soviet RPGs were used extensively during the Vietnam War (by the Vietnam People's Army and Vietcong), Soviet invasion of Afghanistan by the Mujahideen and against South Africans in Angola and Namibia (formerly South West Africa) by SWAPO guerillas during what the South Africans called the South African Border War. In the 2000s, they were still being used widely in conflict areas such as Chechnya, Iraq, and Sri Lanka. Militants have also used RPGs against helicopters: Taliban fighters shot down U.S. CH-47 Chinook helicopters in June 2005 and August 2011; and Somali militiamen shot down two U.S. UH-60 Black Hawk helicopters during the Battle of Mogadishu in 1993.
The RPG has a design that is comparable to a shaped charge explosive. A shaped charge is an explosive charge shaped to focus the effect of the explosive's energy. Various types are used to penetrate tank armour. A typical modern lined shaped charge can penetrate steel armor to a depth of seven or more times the diameter of the charge (charge diameters, CD), though greater depths of 10 CD and above have been achieved.
The shaped charge does not depend in any way on heating or melting for its effectiveness; that is, the jet from a shaped charge does not melt its way through armor, as its effect is purely kinetic in nature.
An RPG comprises two main parts: the launcher and a rocket equipped with a warhead. The most common types of warheads are high explosive (HE) and high explosive anti-tank (HEAT) rounds. These warheads are affixed to a rocket motor and stabilized in flight with fins. Some types of RPG are single-use disposable units, such as the RPG-22 and M72 LAW; others are reloadable, such as the Soviet RPG-7.
The launcher is designed so that the rocket exits the launcher without discharging an exhaust that would be dangerous to the operator. In the case of the RPG-7, the rocket is launched by a gunpowder booster charge, and the rocket motor ignites only after 10 metres. In some other designs, the propellant charge burns completely within the tube.
An RPG is an inexpensive way of delivering an explosive payload over a distance with moderate accuracy. Substantially more expensive guided missiles are used when accuracy is important; the first such missiles trailed a thin wire behind them, through which steering corrections could be sent by the operator while the missile was in flight, for example the AT-3 Sagger; more recently, armies have deployed 'fire-and-forget' missiles that use an internal guidance system, such as an IIR or radar seeker head, for example the Israeli LAHAT.
The HEAT (high explosive anti-tank) round is a standard shaped charge warhead, similar in concept to those used in many tank cannon rounds. In this type of warhead, the shape of the explosive material within the warhead focuses the explosive energy on a copper (or similar metal) lining. This heats the metal lining and propels some of it forward at a very high velocity in a highly plastic state. The resulting narrow jet of metal can defeat armor equivalent to several hundred milimeters of RHA, such as that used in light and medium armored vehicles. However, heavily armored vehicles, such as main battle tanks, are generally too well armored to be penetrated by an RPG, unless weaker sections of the armor are exploited. Various warheads are also capable of causing secondary damage to vulnerable systems (especially sights, tracks, rear and roof of turrets) and other soft targets.
The warhead detonates on impact or when the fuse runs out; usually the fuse is set to the maximum burn of the rocket motor, but it can be shortened for improvised anti aircraft purposes.
Specialized warheads are available for illumination, smoke, tear gas, and white phosphorus. Russia, China, and many former Warsaw Pact nations have also developed a fuel-air explosive (thermobaric) warhead. Another recent development is a tandem HEAT warhead capable of penetrating reactive armor.
So-called PRIGs (Propelled Recoilless Improvised Grenade) were improvised warheads used by the Provisional IRA.
The RPG-29 uses a tandem-charge high explosive anti-tank warhead to penetrate explosive reactive armor (ERA) as well as composite armor behind it. It is capable of penetrating MBTs, such as the M1 Abrams, older model Mark II version of the Merkava, Challenger 2 and T-90.
In August 2006, in al-Amarah, a Soviet RPG-29 damaged the front underside of a Challenger 2, detonating ERA in the area of the driver's cabin. The driver lost part of a foot and two more of the crew were injured, but the driver was able to reverse 2.4 km (1.5 mi) to an aid post. The incident was not made public until May 2007; in response to accusations, the MoD said "We have never claimed that the Challenger 2 is impenetrable." Since then, the ERA has been replaced with a Dorchester block and the steel underbelly lined with armour, as part of the 'Streetfighter' upgrade, which was a direct response to this incident. In May 2008, The New York Times disclosed that an American M1 tank had also been damaged by an RPG-29 in Iraq. The American army is ranking the RPG-29 threat to American armor as high; they have refused to allow the newly formed Iraqi army to buy it, fearing that it would fall into the hands of insurgents.
Various armies and manufacturers have developed add-on tank armor and other systems for urban combat, such as the Tank Urban Survival Kit (TUSK) for M1 Abrams, slat armor for the Stryker, ERA kit for the FV432, AZUR for Leclerc, and others. Similar solutions are active protection systems (APS), engaging closing projectiles, such as the Russian Drozd and Arena, as well as the recent Israeli TROPHY Active Protection System.
The RPG-30 was designed to address the threat of active protection systems on tanks by using a false target to trick the APS. The RPG-30 shares a close resemblance with the RPG-27 in that it is a man-portable, disposable anti-tank rocket launcher with a single shot capacity. However, unlike the RPG-27, there is a smaller diameter precursor round in a smaller side barrel tube in addition to the main round in the main tube. This precursor round acts as a false target, tricking the target's active protection system into engaging it, allowing the main round a clear path into the target, while the APS is stuck in the 0.2-0.4 second delay it needs to start its next engagement. Recent German systems were able to reduce reaction delay to mere miliseconds cancelling this advantage.
The PG-30 is the main round of the RPG-30. The round is a 105-mm tandem shaped charge with a weight of 10.3-kg (22.7-lb) and has a range of 200 meters and a stated penetration capability in excess of 600-mm (24-in) rolled homogeneous armour (RHA) (after ERA), 1500-mm reinforced concrete, 2000-mm brick and 3700-mm of soil. Reactive armor, including explosive reactive armor (ERA), can be defeated with multiple hits into the same place, such as by tandem-charge weapons, which fire two or more shaped charges in rapid succession.
An early method of disabling shaped charges developed during World War II was to apply thin skirt armor or meshwire at a distance around the hull and turret of the tank. The skirt or mesh armor (cage armor) triggers the RPG on contact and much of the molten jet that a shaped charge produces dissipates before coming into contact with the main armor of the vehicle. Well-sloped armor also gives some protection because the shaped charge is forced to penetrate a greater amount of armor due to the oblique angle. The benefits of cage armor are still considered great in modern battlefields in the Middle East, and although similar effects can be obtained using spaced armor, either as a part of the original design or as appliqué armor fitted later, cage armor is preferable due to its low weight and ease of repair.
Today, technologically advanced armies have implemented composite armours such as Chobham armour, which provide superior protection to steel. For added protection, vehicles may be retrofitted with reactive armor; on impact, reactive tiles explode or deform, disrupting the normal function of the shaped charge. Russian and Israeli vehicles also use active protection systems such as Drozd, Arena APS or Trophy. Such a system detects and shoots down incoming projectiles before they reach the vehicle. As in all arms races, these developments in armor countermeasures have led to the development of RPG rounds designed specifically to defeat them, with methods such as a tandem-charge warhead, which has two shaped charges, of which the first is meant to activate any reactive armor, and the second to penetrate the vehicle.
Production by country
Swedish arms makers began to design recoilless antitank rifles in the early 1940s. Their first example was a shoulder-fired, single shot weapon that fired a 20mm projectile, but this was not powerful enough to penetrate heavy tank armour. In the mid-1940s, Swedish arms makers began to try shaped-charge HEAT ammunition. After 1948, 84 mm Carl Gustav recoilless rifles were adopted by Australia, Austria, Belgium, Canada, Germany, USA and several other countries.
The United States Army developed a lightweight antitank weapon (LAW) in the middle 1950s. By 1961, the M72 LAW was in use. It is a shoulder-fired, disposable rocket launcher with HEAT warhead. It is a recoilless weapon, which was easy to use, and effective against armored vehicles. It was used in the Vietnam War. It uses a fin-stabilized rocket. In response to the threat of thicker armor, this weapon was replaced by the AT4 recoilless rifle, a larger & non-collapsable – albeit still single-shot weapon.
The United States Marine Corps uses a different launcher, which is reloadable – the Shoulder-Launched Multipurpose Assault Weapon (SMAW). Unlike the RPG, it is reloaded from the breech-end rather than the muzzle.
- Anti-personnel explosives
- Anti-tank explosives
- RPG-7V2: Reloadable RPG launcher, PG-7VL with ~500 mm RHA penetration, PG-7VR with ~600 mm RHA penetration after ERA
- RPG-16: Reloadable RPG launcher, PG-16 with ~300 mm RHA penetration, higher accuracy and four times the range of the RPG-7
- RPG-18 "Muha (Fly)": One-shot disposable RPG launcher, PG-18 with ~375 mm RHA penetration
- RPG-22 "Netto (Nett)": One-shot disposable RPG launcher, PG-22 with ~400 mm RHA penetration
- RPG-26 "Aglen": One-shot disposable RPG launcher, PG-26 with ~500 mm RHA penetration
- RPG-27 "Tavolga": One-shot disposable RPG launcher, PG-27 with ~750 mm RHA penetration after ERA
- RPG-28: One-shot disposable RPG launcher, with ~1000 mm RHA penetration after ERA
- RPG-29 "Vampir": Reloadable RPG launcher, PG-29V with ~750 mm RHA penetration after ERA
- RPG-30 One-shot disposable RPG launcher, with a 'precursor' forerunner additional sub-munition, intended to defeat Active Defense Systems like Trophy
- RPG-32 "Hashim": Latest variant of RPG 105 mm Caliber, PG-32V with ~650 mm RHA penetration
One of the first instances the weapon was used by militants was on 13 January 1975 at Orly Airport in France, when Carlos the Jackal, together with another member from the PFLP, used two Soviet RPG-7 grenades to attack an Israeli El Al airliner. Both missed the target, with one hitting a Yugoslav Airlines's DC-9 instead.
In Afghanistan, Mujahideen guerrillas used RPG-7s to destroy Soviet vehicles. To assure a kill, two to four RPG shooters would be assigned to each vehicle. Each armor-vehicle hunter-killer teams can have as many as 15 RPG. In areas where vehicles were confined to a single path (a mountain road, swamps, snow, urban areas), RPG teams trapped convoys by destroying the first and last vehicles in line, preventing movement of the other vehicles. This tactic was especially effective in cities. Convoys learned to avoid approaches with overhangs and to send infantrymen forward in hazardous areas to detect the RPG teams.
Multiple shooters were also effective against heavy tanks with reactive armour: The first shot would be against the driver's viewing prisms. Following shots would be in pairs, one to set off the reactive armor, the second to penetrate the tank's armor. Favored weak spots were the top and rear of the turret.
Afghans sometimes used RPG-7s at extreme range, exploded by their 4.5-second self-destruct timer, which translates to roughly 950m flight distance, as a method of long distance approach denial for infantry and reconnaissance. The most noteworthy use of RPGs against aircraft in Afghanistan occurred on 6 August 2011 when Taliban fighters shot down a U.S. CH-47 Chinook helicopter killing all 38 personnel on board including SEAL Team 6 from a range of 220 meters. An earlier anti-aircraft kill by the Taliban occurred during Operation Red Wings, on 28 June 2005 when a Chinook helicopter was destroyed by unguided rocket propelled grenades.
In the period following the 2003 invasion of Iraq, the RPG became a favorite weapon of the insurgent forces fighting U.S. troops. Since most of the readily-available RPG-7 rounds cannot penetrate M1 Abrams tank armor from almost any angle, it is primarily effective against soft-skinned or lightly armored vehicles, and infantry. Even if the RPG hit does not completely disable the tank or kill the crew, it can still damage external equipment, lowering the tank's effectiveness or forcing the crew to abandon and destroy it. Newer RPG-7 rounds are more capable, and in August 2006, an RPG-29 round penetrated the frontal ERA of a Challenger 2 tank during an engagement in al-Amarah, Iraq, and wounded several crew members.
RPGs were a main tool used by the FMLN's guerrilla forces in the Salvadoran Civil War. For example, during the June 19, 1986 overrun of the San Miguel Army base, FMLN sappers dressed only in black shorts, their faces blacked out with grease, sneaked through barbed wire at night, avoiding the searchlights, they made it to within firing range of the outer wall. Using RPGs to initiate the attack, they blew through the wall and killed a number of Salvadorean soldiers. They eliminated the outermost sentries and searchlights with the rockets, then made it into the inner wall, which they also punched through. They were then able to create mayhem as their comrades attacked from the outside.
During the First (1994–1996) and Second Chechen Wars (1999–2009), Chechen rebels used RPGs to attack Russian tanks from basements and high rooftops. This tactic was effective because tank main guns could not be depressed or raised far enough to return fire, in addition, armor on the very top and bottom of tanks is usually the weakest. Russian forces had to rely on artillery suppression, good crew gunners and infantry screens to prevent such attacks. Tank columns were eventually protected by attached self-propelled anti-aircraft guns (ZSU-23-4, Tunguska-M1) used in the ground role to suppress and destroy Chechen ambushes. Chechen fighters formed independent "cells" that worked together to destroy a specific Russian armored target. Each cell contained small arms and some form of RPG (RPG-7V or RPG-18, for example). The small arms were used to button the tank up and keep any infantry occupied, while the RPG gunner struck at the tank. While doing so, other teams would attempt to fire at the target in order to overwhelm the Russians' ability to effectively counter the attack. To further increase the chance of success, the teams took up positions at different elevations where possible. Firing from the third and higher floors allowed good shots at the weakest armor (the top). When the Russians began moving in tanks fitted with explosive reactive armor (ERA), the Chechens had to adapt their tactics, because the RPGs they had access to were unlikely to result in the destruction of the tank.
Using RPGs as improvised anti-aircraft batteries has proved successful in Somalia, Afghanistan and Chechnya. Helicopters are typically ambushed as they land, take off or hover. In Afghanistan, the Mujahideen often modified RPGs for use against Soviet helicopters by adding a curved pipe to the rear of the launcher tube, which diverted the backblast, allowing the RPG to be fired upward at aircraft from a prone position. This made the operator less visible prior to firing and decreased the risk of injury from hot exhaust gases. The Mujahideen also utilised the 4.5-second timer on RPG rounds to make the weapon function as part of a flak battery, using multiple launchers to increase hit probabilities. At the time, Soviet helicopters countered the threat from RPGs at landing zones by first clearing them with anti-personnel saturation fire. The Soviets also varied the number of accompanying helicopters (two or three) in an effort to upset Afghan force estimations and preparation. In response, the Mujahideen prepared dug-in firing positions with top cover, and again, Soviet forces altered their tactics by using air-dropped fuel-air bombs on such landing zones. As the U.S.-supplied Stinger surface-to-air missiles became available to them, the Afghans abandoned RPG attacks as the smart missiles proved especially efficient in the destruction of unarmed Soviet transport helicopters, such as Mil Mi-17. In Somalia, both of the UH-60 Black Hawk helicopters lost by U.S. forces during the Battle of Mogadishu in 1993 were downed by RPG-7s.
- Grenade launcher
- Rifle grenade
- Shoulder-launched missile weapon
- Panzerfaust 3
- Type 69 RPG
- Yasin (RPG)
- Peter E. Kaiser (2001). Jarold E. Brown, ed. Historical dictionary of the U.S. Army. ISBN 978-0-313-29322-1. Retrieved 24 January 2011.
- How Rocket-Propelled Grenades Work howstuffworks.com
- "RPG-7 - Rocket-Propelled Grenade Launcher - History, Specs and Pictures - Military, Security and Civilian Guns and Equipment". Militaryfactory.com. 2013-11-21. Retrieved 2014-05-08.
- "The Rocket Propelled Grenade". Osprey Publishing. Retrieved 2014-05-08.
- John Pike. "Shaped Charge". Globalsecurity.org. Retrieved 2014-05-08.
- "Rocket Propelled Grenades, about.com". Terrorism.about.com. Retrieved 2014-05-08.
- "CCB-18 Memorial Fund". Mrfa.org. Retrieved 2014-05-08.
- "Modern Pirate Weapons - RPG7 - MaritimeSecurity.com". maritimesecurity.com. Archived from the original on 16 February 2009.
- "Military Photos". Strategypage.com. Retrieved 2014-05-08.
- Ze'ev Schiff (2006-08-06). ""Hezbollah anti-tank fire causing most IDF casualties in Lebanon", ''Haaretz'' 2006-08-06". Haaretz.com. Retrieved 2014-05-08.
- "T-80U and T-90 Trials 20.10.99". Armor.kiev.ua. 1999-10-20. Retrieved 2014-05-08.
- Sean Rayment (May 12, 2007). "MoD kept failure of best tank quiet". Sunday Telegraph.
- Michael R. Gordon (May 21, 2008). "Operation in Sadr City Is an Iraqi Success, So Far". The New York Times.
- "RPG-29 vs M1A2". LiveLeak.com. Retrieved 2014-05-08.
- Super RPG threat, Army passes on system that could defeat RPG-29, DoD officials say , By Greg Grant
- ""Базальт" завершил разработку и испытания РПГ-30". ВОЙНА и МИР (Russian). 2008-11-19. Retrieved 2008-11-20.
- "Sturmgeschütze vor!". Stugiii.com. Retrieved 2014-05-08.
- "Relative armour thickness". Panzerworld.net. 2013-11-18. Retrieved 2014-05-08.
- Ward Carroll (2007-07-18). "The MRAP Cage Fight". Defense Tech. Retrieved 2014-05-08.
- Grant Wardlaw, Political terrorism: Theory, Tactics and Counter-Measures (Cambridge: Cambridge University Press, 1989), 27
- Popular Mechanics Mar 2004. Books.google.com.my. Retrieved 2014-05-08.
- John Pike. "The RPG-7 On the Battlefields of Today and Tomorrow, by Mr. Lester W. Grau, Foreign Military Studies Office, Fort Leavenworth, KS, Infantry May-August 1998". Globalsecurity.org. Retrieved 2014-05-08.
- Dead Men Risen, By Toby Harnden. Books.google.com.my. Retrieved 2014-05-08.
- Spencer, David E. From Vietnam to El Salvador: The Saga of the FMLN sappers and Other Guerrilla Special Forces in Latin America; Praeger Publishers (1996)
- Grau, Lester W. (January 1997 (original publication)). "Russian-Manufactured Armored Vehicle Vulnerability in Urban Combat: The Chechnya Experience". Fort Leavenworth, Kansas: Foreign Military Studies Office. Retrieved June 16, 2010. Check date values in: